2000 LIFE LINE TYPE III MODULAR AMBULANCE RECONDITIONING LIST

SN102

 

XX         Engine: Check glow plugs and controller. Change oil and

             filter. Check belts, hoses, radiator and water pump.

            Change fuel filter and air filters. 98,326 miles.

XX        Check charging system and run voltage check.

XX       Check power steering, steering sector and front end.

XX        Check springs and shocks.

XX       Check rear axle. Add 1# fluid. No leaks.

XX        Check brakes: 2 new calipers and new brake pads rear. Front OK.

XX        Check exhaust system.

XX        Check wipers/washers/horn/DOT lights. 2 New back up lights.

            1 New license plate light. Repair wipers.

XX        Check heat and air: Add 12 oz. 134 freon.

XX       Check transmission: Fluid and filter change 89,206 miles.

            No leaks.

XX       Check drive shaft and Universal joints.

XX        Check Granning air ride system: Repair 2 leaks. Wire compressor

            hot with shoreline plugged in.

XX       Check tires: Install 6 new all season tires.

XX        Check emergency lights and siren.

XX       Check ambulance electrical: 2 new fluorescent bulbs.

            1 New rocker switch. New flood light driver’s side, install

            2 new Whelen 73 lens, red/clear. 1 Module disconnect switch.

            1 New air horn solenoid.

XX       Exterior: Paint where needed. Change green stripe to blue.

            2 New rear wheel moldings. 2 New rub rails. Replace hub

            cap. 1 New nut and stud extender on wheel cover. Replace

            reflective vinyl. Buff aluminum. Paint door jams.

XX        Interior: 4 Gas hold opens 40#. 4 Gas hold opens 20#. One

           lock and barrel latch. Remove stickers and clean interior.

            Clean interiors of exterior compartments.